Scope of Application

These guidelines are applicable to double-deck car parking hoists used solely for the raising of motor vehicles, which do not pass through any floor and the height of travel of which do not exceed 3.5m.

Guide to Safety on Double-Deck Car Park

The double-deck car park normally has two parking spaces, one above the other. The vehicle in the lower parking space has to be removed in order to allow lowering of the platform holding the vehicle at the upper stop position. Other mechanised car parking system which has a height of travel exceeding 3.5 m or passes through any floor, would be subject to the control of the Lifts and Escalators Ordinance (Cap. 618).

Building Requirements

Prior to the commencement of works every person for whom the installation of a double-deck car park is to be carried out shall appoint an authorized person or a registered structural engineer. Such appointed person should submit to the Building Authority the proposal together with corresponding structural justification demonstrating the stability of the mechanised car parking system and structural adequacy of the building in which the system is to be installed.

General Requirements

  1. Safe and adequate access to the platform controls must be provided for the operator/user.
  2. Adequate electricity supply is available for operation of the double-deck car park.
  3. If the double-deck car park is installed in the open area, the equipment including the electrical components should be of a design suitable for outdoor environment.
  4. The double-deck car park is prohibited from being used to lift persons or vehicles with persons.

Safety Features

Mechanical Locks

The platform holding the motor vehicle shall be mechanically locked automatically when it reaches the upper stop position. A visual indication or audible signal will be given, if the platform has not reached the upper or lower stop position or has not been mechanically locked.

Overload Device

Unless there are other means to prevent lifting a motor vehicle exceeding the capacity of the platform/equipment, an overload device should be installed to prevent any movement of the platform and to give an alarm when the load on the elevating platform is in excess of the rated capacity.

Deadman Control

The movement of the platform shall be stopped, unless the operator keeps his hand on the local control device during the raising or lowering process.

Key Switch

A key-locked switch to avoid any unauthorised operation should be provided.

Chocks

Automatic or permanent chocks shall be provided to arrest any unpowered movement of the vehicle on the platform.

Emergency Operation

A device shall be provided to raise and lower the platform when the normal power supply fails.

Operation and Maintenance

  1. The double-deck car park shall not be used for lifting persons or vehicles with persons.
  2. Do not use the platform to raise over-sized or over-weight vehicles. Notice in Chinese and English stipulating the safe working load and maximum allowable vehicle size should be displayed.
  3. Do not allow children playing with the operation of the platform. If the car parking system is not in operation, take away the key from the control panel to avoid tampering.
  4. The platform shall not be lowered when the lower deck is occupied. The floor area directly beneath the platform should be clearly marked.
  5. Good maintenance is essential to safety. So ensure the car parking system is always in good working condition by following the contractor's advice.

These guidelines are issued by General Legislation Division of Electrical and Mechanical Services Department. Compliance with these guidelines does not of itself confer immunity from any legal obligation.